Ordinary Portland Cement With Quarry Dust Of Concrete
- صفحه اصلی
- Ordinary Portland Cement With Quarry Dust Of Concrete
Ordinary Portland Cement (OPC), lateritic sand, river sand and quarry dust were used for all mixes in this research. In obtaining the effect of elevated temperatures, the study considered 0 °C ...
به خواندن ادامه دهید
PROPERTIES OF GREEN CONCRETE CONTAINING QUARRY ROCK DUST AND MARBLE SLUDGE POWDER AS FINE AGGREGATE ... with the oxide composition of ordinary Portland cement. 83 . VOL. 4, NO. 4, JUNE 2009 ISSN ...
به خواندن ادامه دهید
Quarry dust might be used as a partial substitute for river sand in making concrete. This would have the dual benefit of helping to preserve river sand and …
به خواندن ادامه دهید
Therefore, this paper highlights the study on the suitability of Quarry Dust Fine Powder (QDFP) as cement replacement material in different w/b ratio by employing different …
به خواندن ادامه دهید
Materials used: Ordinary Portland cement (43 grade) was used for the study. Natural river sand has been used for the study in making the control specimens. Quarry dust for the study has been col-lected from the nearby stone quarry at Milekkal near Kovaipudur. Earlier investigation (Sahu et al.
به خواندن ادامه دهید
For considering M60 grade concrete the Quarry Dust is replaced to natural sand directly i.e. maintained constant & steel fiber are varied in the percentage of 0.5%, 1%, & 1.5% the test were ...
به خواندن ادامه دهید
The compressive strength of concrete built with river sand and quarry dust as fine aggregate was examined in this study. Ordinary Portland cement (OPC) was blended with river sand and quarry dust at five levels, namely 10%, 20%, 30%, 40%, and 50%, by partially substituting OPC with river sand and quarry dust.
به خواندن ادامه دهید
The numerous demanding application of concrete is not readily met with Ordinary Portland Cement (OPC) alone. To meet up the demand and as well as ensured the green concrete durability, it has becomes necessary to incorporate mineral additions with the best combination of others by-product as replacement to improve the …
به خواندن ادامه دهید
Many studies investigated the effects of waste quarry dust incorporation as a replacement to ordinary Portland cement, with researchers, (e.g., Kartini et al., 2014;Rathore et al., 2020; Imran and ...
به خواندن ادامه دهید
Concrete mechanical properties could be improved through adding different materials at the mixing stage. Quarry dust (QD) is the waste produced by manufactured sand machines and comprise approximately 30–40% of the total quantity of QD generated. When it dries, it transforms into a fine dust that poses a tremendous hazard to the …
به خواندن ادامه دهید
It was found that concrete with 30% GGBS and 20% fly ash and the remaining 50% ordinary portland cement as cementitious materials along with 40% QD and 30% RCA as aggregate replacements gives adequate compressive strength and performs better in aggressive environments as compared to traditional concrete.
به خواندن ادامه دهید
Portland cement (PC) is an imperative component of concrete, and it is not universally sustainable. Sustainability issues associated with Portland cement …
به خواندن ادامه دهید
From the x-ray fluorescent spectrometry test result, the quarry dust displays some similar characteristics with the Ordinary Portland Cement (OPC) where it …
به خواندن ادامه دهید
Ordinary Portland cement of 43 grade (IS), superplasticizer (ASTM Type I). Chloride penetration resistance, compressive strength, freezing–thawing resistance, J-Ring, and slump-flow test. SL, S, C : Limestone stone dust (0–75%), marble stone dust (5–15%), natural sand, and gravel. Ordinary Portland cement of 53 grade (IS), superplasticizer
به خواندن ادامه دهید
In this experimental study Ordinary Portland Cement 53 grade confirming to IS 12269: 2013 specification was used as an important binder [14]. Physical properties of the cement
به خواندن ادامه دهید
Workability and water absorption Studies were done for concrete with Quarry Rock Dust and compared with the Conventional Concrete . November 2016, Volume 3, Issue 11 JETIR (ISSN-2349-5162) ... CEMENT The Ordinary Portland Cement (OPC) 53 grade used in the project work. This is used as main binder in the mixes.
به خواندن ادامه دهید
Concrete grade considered for this experimental study is M30 with 53 grade of Ordinary Portland Cement. About 50% and 75% cement was replaced by fly ash. Sand is replaced by the 5% of coir pith and 25%, 50% and 75% of quarry dust. ... Compared to split tensile strength flexure strength is increased when increasing the quarry dust in …
به خواندن ادامه دهید
The ordinary portland cement (OPC) utilized was obtained from the local market in Ado Ekiti while the quarry dust was obtained from Ijere in Ekiti State, calcined clay and laterite were obtained from Ire, Ekiti State and calcite from Auchi-Igara region of Edo State in Nigeria.
به خواندن ادامه دهید
Al and Si ions in the raw materials are highly influenced by the type of activator being utilized. The weight ratio of sodium silicate to sodium hydroxide solution was 2. Ordinary Portland cement was used to make the concrete, with the chemical composition listed in Table 1. For the manufacture of concrete, river sand with a density …
به خواندن ادامه دهید
cement dust could result in long-lasting and reasonably priced building materials. [5]. Pozzolanic material is one of the most frequently used partial replacements for ordinary Portland cement (OPC) in concrete, and it can improve the quality and durability of concrete[6]. Throughout the
به خواندن ادامه دهید
concrete with quarry dust concrete 1Hyginus E. Opara, 2Uchechi G. Eziefula, 3Bennett I. Eziefula ... Ordinary Portland cement of grade 42.5R manufactured to [20] standards was used. River
به خواندن ادامه دهید
10% Ordinary Portland cement is replaced by 10% waste from granite sawmill, which is studied to obtain sustainable ecological cement, which provides …
به خواندن ادامه دهید
Ordinary Portland cement (OPC) was blended with river sand and quarry dust at five levels, namely 10%, 20%, 30%, 40%, and 50%, by partially substituting OPC with river sand and quarry dust. River ...
به خواندن ادامه دهید
Concrete with 50 % river sand and 50 % quarry dust performed better in flexure for both Bamboo Reinforced Concrete (BRC) and Steel Reinforced Concrete (SRC) at 28 days with strengths of 12.75 N/mm ...
به خواندن ادامه دهید
This research was conducted to examine the potential of basaltic crusher dust as a partial replacement for Portland Pozzolana cement in hollow concrete block …
به خواندن ادامه دهید
The numerous demanding application of concrete is not readily met with Ordinary Portland Cement (OPC) alone. ... (2015). Study of Concrete Involving Use of Quarry Dust as Partial Replacement of Fine Aggregates. 5(2): 2278-8719. Peter, A. C. (2016). Chapter 21-Concrete mix Design. Civil Engineering Materials, 201-217. …
به خواندن ادامه دهید
ash and quarry dust in high-strength concrete to develop a sustainable concrete: A Study on the Mechanical and Durability Properties S.R.R. Teja Prathipati, Yeswanth Paluri, ... The materials used in this study included laterite soil, quarry dust and Ordinary Portland cement. 2.1.1 Laterite soil. As shown in Figure 1, the experimental soil was ...
به خواندن ادامه دهید
An English bricklayer made the first portland cement early in the 19th century by burning powdered limestone and clay on his kitchen stove. With this crude method, Joseph Aspdin of Leeds laid the foundation for an industry that annually processes literally mountains of limestone, clay, cement rock, and other materials into a powder so fine, it ...
به خواندن ادامه دهید
Optimizing Cement Quarry Dust Ratio in Concrete Asphalt Using for Industrial Purposes D.H.J.M.V.R. De Silva 1, G. Udayakumara ... M40 Cement: Ordinary Portland cement (Strength class 42.5 N) which is compatible with natural sand, quarry dust & sea sand complying with BS EN 12620:2013 was used.
به خواندن ادامه دهید
quarry dust, sawdust, concrete debris, fly ash, coconut shells among others which are produced from milling stations, ... Ordinary Portland Cement (OPC) in concrete. OPC was replaced with RHA by weight at 0%, 5%, 10%, 15%, 20% and 25%. 0% replacement served as the control. Compacting
به خواندن ادامه دهید
As a result, quarry dust and river sand are suggested as construction materials for making concrete, and can be used to replace river sand up to 30% of the time to achieve the needed compressive strength of not less than the standard Keywords: River sand; Quarry dust; Ordinary Portland Cement; Compressive strength DOI: 10.7176/JEES/11-9-06 ...
به خواندن ادامه دهید
Aluminum dross, cement, sand, and quarry dust were used in a variety of proportions with a constant percentage of fly ash for the design of nine concrete mixtures. Aluminum dross was replaced by 5 ...
به خواندن ادامه دهید
Ordinary Portland cement (OPC) with our local additive Rice Husk Ash (RHA) which is known to be super pozzolanic in concrete at optimum replacement percentage which will help to reduce the cost of ...
به خواندن ادامه دهید
From the x-ray fluorescent spectrometry test result, the quarry dust displays some similar characteristics with the Ordinary Portland Cement (OPC) where it comprises a high composition of …
به خواندن ادامه دهید
Sukesh et al. (2013) investigated that the usage of Quarry dust, the characteristics of Portland cement, and the fine and coarse materials utilized in …
به خواندن ادامه دهید
چه بخواهید با ما کار کنید و چه علاقه مند به کسب اطلاعات بیشتر در مورد محصولات ما هستید، مایلیم از شما بشنویم.